CHINA SOUTHERN AIRLINES 中国南方航空公司 Aircraft Tail No. 飞机号： Maintenance Station 维修站： Completion Date 完成日期： Revision&Version 2009-09-01 修订版本： R1 Written/Revised by 詹锦文 编写/修订： 2009-07-30 B737NG飞机每日维护工作单 – 机电 – 客舱 Job Card 工卡号: 38M0500504-3 JC Title 工卡标题 B737NG DAILY MAINTENANCE CHECKLIST - M&E - CABIN B737NG每日维护工作单 - 机电 - 客舱 Reviewed/Approved by 张少娟 审核/批准： 2009-07-30 Mechanic 工作者 NOTE : The task card is written per B737NG MS. 注： 本工卡根据B737NG维修方案编写而成。 1. Visually check and make sure that all the airworthiness placards or markings in the passenger cabin are legible and no missing. 目视检查并确保客舱内的所有适航性标志/标牌没有丢失且清晰可读。 _________ 2. Check left and right passenger cabin doors and sealant are in good condition and the pressure indicators of the escape slide pack inflation cylinder are normal. 检查客舱左右登机门和勤务门及其封严条完好，撤离滑梯包充气气瓶压力指示正常。 3. Check all cabin exits and emergency exits are in normal condition. 检查所有客舱出口和应急出口正常。 _________ _________ 4. Check cabin window inner panes for obvious damage. Check the emergency hatches are closed and locked. 检查客舱内层玻璃无明显损坏，应急舱口盖关好锁住。 5. Check the life-vest and oxygen mask for demonstration are in place and in good condition. 检查示范用的救生衣和氧气面罩在位并状况良好。 NOTE : This step is not applicable to the airplanes operated by XINJIANG branch. 注： 新疆执管的飞机除外。 6. Check the first aid kits (three or two) are in position and make sure the paper strip seal is good. 检查机上急救包(3个或2个)位置安装正确，封印完好。 7. Check that protective breathing equipment or smoke hoods for good seal. 检查保护性呼吸设备或防烟面罩在位，包装及封严良好。 _________ _________ _________ _________ 8. Make sure the portable oxygen cylinders are all secured, The fill port is capped , The pressure is not less than 1800PSI and the oxyegen masks are present and clean . 确保手提氧气瓶固定牢固，充气接口有防尘盖，压力不低于1800PSI，氧气面罩在位且清洁。 _________ 9. Check that portable fire extinguishers cylinders are all secured, There are no visible signs of physical damage, no broken handle seal, and the pressure is in the green band (except for water fire extinguishers) . 检查手提灭火瓶固定牢固，瓶体没有可见的物理损伤的迹象，手柄的铅封完好，压力指示在绿区(水质灭 火瓶除外)。 _________ 10. Check that portable water fire extinguisher is secured and in good condition, lock-pin and lockwires are installed correctly, there is no visible signs of physical damage. 检查手提水质灭火瓶安装在位且状况完好，手柄打好保险，并无可见的物理损伤。 _________ 11. Make sure the waste compartment fire extinguishers in the lavatories are all secured and not released. 确认厕所废物箱灭火瓶固定牢固，没有释放。 _________ Aircraft Effectivity飞机适用范围: ALL Page页码 1 of 2
Job Card 工卡号： JC Title 工卡标题 38M0500504-3 B737NG DAILY MAINTENANCE CHECKLIST - M&E - CABIN B737NG每日维护工作单 - 机电 - 客舱 Mechanic 工作者 12. Visually check that the emergency flashlights (2 flashlights are located under each double attendant Seat) are present, and the LED flashing in less once every 10 seconds. Replace the battary pack if LED is dim or the flashing interval exceeds 10 seconds. 目视检查应急手电筒(每个双座位的乘务员座椅下有2个手电筒)在位，LED至少每10秒闪烁一次。若LED 暗亮或闪亮间隔超过10秒，应更换电池。 _________ 13. Do an operational check to make sure the following interior and exterior emergency lights operate correctly: overhead aisle lights, exit indicators, exit signs, slide lights, overwing hatch lights, escape lights and floor proximity lights. 操作检查并确保下列机内外应急照明灯正常：过道头顶灯、出口指示灯、出口标志灯、应急滑梯灯、翼上 出口灯、撤离灯和地板应急灯。 _________ ***END OF CARD*** Aircraft Effectivity飞机适用范围: ALL Page页码 2 of 2