问题点描述(Defect description)
Color transfer 颜色迁移
vamp/upper wrinkling鞋面皱纹 Stitching not even车线不平均 Tricot shows up特丽可得露出来 Lasting not even攀帮不均匀 Shank too loose铁心太松
back counter not straight后包歪 Outsole come off底脱胶 Wrong pattern 纸板错误 Wrong material材料错误 Wrong cutting裁断错误 Wrong last 楦头错误 Wrong color颜色错误 toe sinking鞋头凹陷
color different/variation色差 upper damaged鞋面破损 Not in pair不配双
Upper Crooked鞋面弯曲 Crooked屈曲,不平顺
vamp length not in pair 鞋头长度不配双/鞋口深浅不一
lasting off center攀帮歪
outsole not in right position 大底贴歪
Back strap too high(low, long, short)后拉带太高 Abrasion磨损
Stitching not on the mark不照记号齿车 Bump on insole中底发角 Bump /发角（花脚、花角） Vamp open up鞋面掀开 Wrapping not tight攀帮不紧 Shank not straight铁心不正 Cementing comes off脱胶
Elastic too weak松紧带弹性不佳 Glue marks on heel鞋跟胶渍
Cementing not good enough粘着力不佳 cleanness not enough清洁度不佳 Vamp split off 鞋面爆开
Color not matching颜色不配双 loose thread脱线/炸线 Broken thread 断线 Turn yellow变黄 Turn dark变黑
6 / 32
Pinch in 缩进去 Flatten变平 Rough粗糙 Roughing打磨 X-ray透痕
dirty脏/污渍/污染
Glue mark胶渍/胶水痕迹 Hairy 起毛
gaping 缝隙/胶洞/大底和鞋面没有贴好，有空隙/老鼠洞
outsole lack of glue大底欠胶 Chippings碎屑 Get mildew发霉
Back height different后跟高度不一 over glue溢胶
Outsole bottom dirty大底底部脏 Wet operation 湿场作业
Trimming and sorting 削整及分皮 Soaking 浸水 Fleshing 削肉 Unhairing 脱毛 Bating 酵解软化 Splitting 起层 Shaving削面 Skiving削边 Setting out 张皮
dry operation 干场作业 drying 干燥
conditioning 回湿 staking 铲软 buffing 磨皮
Finishing 后处理(指固定) Brushing擦色
Out of shape 变形
Outsole out of shape 塌陷/大底变形 Shape形状 Delasting 脱楦
Toe spring different头翘高低 thread residue/线头 rework/返修
on material 材料擦伤、刮伤 Modification/修正
Minor accepted/轻微接受 Critical rejected/严重剔除
Platform wrinkled/水台包风（起皱） Platform broken水台破损 toe part crooked/鞋头歪 paint shedding/掉漆 Come off/脱落
insock comes off/鞋垫、中皮开胶 Stick outsole/贴底
Outsole with bad cementing贴底不良 back counter wrinkled/后包皱 Back counter uneven/后包不圆顺
Toe cap length different/鞋头盖长短不一 Bowknot rolled up蝴蝶结卷起 studs unsmooth铆钉不平
chemical sheet x-ray 港宝透痕 bowknot insecure蝴蝶结不牢固 Bad printing印刷不良
thread residue untrimmed线头未修剪 Insole wrinkled中底皱
Zipper puller is not smooth拉链头上端不光滑
Top of zipper is not closed拉链上端不密合 Zipper position inconsistent拉链位置上下不一致
Upper shining is not the same鞋面亮度不一致
Insole cow suede not insecure垫脚牛绒不牢固Insole cow suede not trimmed well垫脚牛绒没修剪平齐
Insole cow suede hair length is difference牛绒毛长短
elastic broken 松紧带断裂
folding is not smooth 折边不顺 cow suede layered牛绒分层 skipped stitch跳针 Fuzzy 毛边、须边
strap positions different 条带位置不同 end of binding is broken滚口尾端散开 less cementing 欠胶 Bad stitching 车线不良
Stitching not even车不平均
Insole and outsole not on the same line 中底和大底不平齐
7 / 32
Platform color difference 底台色差 Insock wrinkle中皮/鞋垫皱 buckle damage扣子打坏
The joint of outsole & platform not smooth/底台与大底接头不平齐 press mark 压痕 crooked/魔术带歪斜
Velcro strap distance is inconsistent/魔术带间距大小不一致
Size label is not tear completely/尺码标未撕干净
buckle is loose/饰扣松动
Out of shape by pressing/挤压变形 welt not in pair/鞋子沿条不配对
reinforcing band exposed/补强带暴露 lasting uneven 拉邦不贴楦/拉邦不顺 upper diamond shedding鞋面掉钻 Topline wrinkling鞋口皱
both sides of topline wrinkling 鞋口内外皱 Decoration strap height different 装饰条带高度不一
Eyelet stay wrinkling护眼片皱 Eyelet stay crooked 护眼片歪
Eyelet stay foam untrimmed 接护眼片海绵未清洁干净
Toe damage 鞋头位置修补不良（鞋头坏） Collar broken down领口凹陷不顺 Back part wrinkled后帮皱
Toe section exposed鞋头切片外露
Back part not lasted properly后帮未能拉到位
Shoelace unsmooth鞋带不顺
Decorations position not match装饰品不对称
Upper color bleeding鞋面溢色
Outsole stitching exposed大底车线外露 Upper embroidery loose thread鞋面电绣浮线
Welt unsmooth沿条不顺
pen marks银笔线未清洁干净
sponge untrimmed clean海绵未清洁干净 upper split鞋面分层 Lining split内里分层l Insole split垫脚分层
Decoration bow opening装饰结外翻
lining not lasted under the insole内里没攀下去
lining wrinkling内里皱 insole over glue垫脚透胶
material not combined well（分层）材料贴合没贴好
outsole edge unsmooth大底磨边不圆顺 back part stitching crooked 后跟车线歪斜 zipper position is too height外侧拉链组合太高
toe unsmooth 鞋头不平顺 heel with scratches 后跟刮花
back counter lining wrinkling 后套里皱 heel x-ray 后跟透痕 fold marks折痕
laser hole not through completely鞋面冲孔未冲穿/镭射孔未打透(装饰类的孔都叫镭射孔)
logo printing unclearly 商标印刷不清楚 heel crooked 后跟歪
stitching hole appears on upper 鞋面有针孔 binding unsmooth 包边不顺 injection badness 注塑不良、
insock not combined well 垫脚没组合好 toe post leather damaged 夹角破皮 decorations come off 饰花脱落 insole bad stitching中低车线不良 toe spring too high 鞋头翘度过高 decorations come off 饰品掉落 scratches on upper 鞋面刮花
bowknot size not in pair蝴蝶结大小不一 bowknot crooked 蝴蝶结歪
seam of heel part damaged 后包合缝破 edge trimmed not good 修边不到位 coating changed color 涂层变色 Lack of injection material 缺料 upper damaged面料不良
ribbon not in right position织带错位 Glue mark on foot bed鞋床/脚床胶渍
PE paper not trimmed well PE纸未清洁干净laced hole not through completely 鞋带孔未穿透
Coating指涂层，一般是针对金属
8 / 32
Painting指着色
painting on outsole is not good.大底涂边不顺
edge over painting 涂边溢边
Missing label 贴标漏贴
vamp strap is mismatches鞋面条带错位 upper faded鞋面掉色
upper brushing not same鞋面擦色亮度不一 missing stitching 漏针/跳针
outsole on heel part not stick properly跟角底片未贴到位
The production toe cap is wider than confirmation sample
大货鞋头片长度比样鞋长
for solid pack, the box label didn't show up side单码装内盒标未朝开箱这面 needle hole针孔
instep strap twist 鼻梁带歪
outsole pictogram different from cfm sample大底成分标与确认样不一样 rubber strap on foxing not good /foxing line is broken水线不良
foxing line damage
the shoes in box with different size错码 binding width not in pair滚边宽窄
Inside of quarter is not smooth 内腰不顺 the production shoes with wrapping tissue in, but the packing instruction shows no need tissue包装资料上写不用塞纸，大货有塞
The composition label is stuck lining instead of stick on outsole from packing instruction shows
材质标贴于内里，而包装要求贴大底 The carton stick two labels on both side mark instead of only stick one side mark from packing instruction shows
外箱标贴于两侧唛，包装要求贴一侧唛 For mix pack, the QTY umber on label is wrong混码贴标双数不正确
Insole is out of the right position中底移位 Back counter out of shape后包变形
The eyelets didn't fixed properly鞋眼扣没
订好
the straps position on upper are not match/脚背带位置不对称
outside of right foot shows upwards,should be left foot as packing instruction;右脚外侧朝上，包装资料中显示正确的方式应该是左脚外侧朝上
minor color variation on welt沿条有轻微色差
The collar stitching shows white color out
鞋口露白色底线 The production zipper puller is darker than
cfm sample拉链头颜色比确认样深 The production outsole welt color has
slightly different than cfm sample沿条有轻微色差 the velcro got damage by dryer machine 毛刺、魔术贴烘断
Velcro got burned魔术勾烘焦
The decoration strap on back counter is stay downwards饰带下吊
Ornament comes off小饰片脱落
Anti mold sticker stick inside of box lid (packing shows need to stick inside of box body one short side which the side without hole) 防霉片贴于盒盖
Instep decoration wrinkle not in pair脚背抓皱不良
Packing way is wrong包装方式不正确
Width of Velcro different with cfm sample魔术带宽度与验货鞋不一样
color variation on cow suede反毛皮色差 backing material with white
edge(slightly ,not too much) 皮料有贴白色布轻微露白
Box sticker doesn't show leather mark 无皮质标识
The heel hardness of production is softer than cfm sample后跟较CFM样硬度不足 Leather with bad finishing皮料后处理不良 Request factory to improve it in future orders要求工厂后续改进
back counter height different后包高低 Topline of boot shaft is smaller 3mm than
9 / 32
cfm sample鞋口比确认样小3mm Outsole is lighter than cfm sample 大货大底比确认样浅
Production upper is not shiny as cfm sample 大货表面没有确认样亮
Lining exposed 内里外露
foxing dirty/边墙、围条污染
Production didn’t stick anti-thieft label 大货没有贴防盗标 Instep wrinkling脚背皱
Upper with uneven finishing鞋面后处理不均匀
Toe cap is wider 4mm than CFM sample大货鞋口深度比样鞋长4mm Boot shaft with different height 靴筒高低
PE foam/
珍珠棉（如下）Foam/泡沫棉(如下)
PE foam put inside of boot shaft/靴捅塞了珍珠棉
Foam put inside of toe part/鞋头放了泡棉 Strap didn't stitch on boot shaft tightly条带组合不贴鞋面
Production back part of boot shaft were lower 6-8mm than cfm sample靴筒后包高
度比样鞋矮6-8mm
masking tape was not tear off completely 美纹纸未撕干净/大底胶纸未撕干净 The fur on topline and outside is less than Toe puff exposed 前港宝外露 Lasered not clean雷射杂物
Outsole lack of glue, didn't stick with top lift properly 后跟大底片与天皮组合位开胶 cfm sample.
筒口和外腰毛毛密度比样鞋稀 The fur on topline got damaged 筒口毛毛散口
Upper color faded by cleaner 清洁剂导致鞋面掉色
Diamond color faded水钻掉色 Lining not last well内里未攀牢
Lining not stick well 内里未贴顺、爆开 Label directly put on box, in the packing instruction should stick on one short side of box吊牌直接放于外箱中
Decoration is not attach on upper closely饰品不贴合鞋面
Buckle didn’t fix tightly on upper鞋扣未打牢 Strap damaged条带破损
Side ornament strap width not in pair腰片不配双
Outsole paw part unsmooth脚掌处不直顺 Outsole bottom color faded to the foxing大底窜色到围条上
Decorations material edge fuzzy/饰片毛边 The foam on back counter is not full filled后领口海棉下吊
fabric damaged编织布脱丝
Lasted upper stitching exposed网脚线外露 Toe binding with height different头厚不一致 Collar/Toe line is not smooth, the foam exposed
领口不圆顺、露海棉
Eyelet fix crooked护眼、鞋眼冲偏
stitching distance is uneven针车边距不一/车线边距宽
Logo not print on sock鞋垫没印刷 Wax stains on zipper拉链上有蜡渍 Snake grain not in pair蛇纹不配双
Insock not in the right position中皮、鞋垫未垫好
Upper grain not in pair鞋面纹路不配双 toe puff x-ray 前港宝透痕
10 / 32
insock didn't stick good on insole中皮、鞋垫未粘牢固
Production lacing way is wrong(left side)左边鞋鞋带穿错
Outsole open, didn't stick on heel properly大底片与跟组合开胶
Decoration strap/zipper（与decoration连用的都是没有作用的，只起到装饰的效果） Per factory this already got cfmd by customer, but E service didn't get any comments from Interco.工厂说客人已确认，但是Eservice还没收到Interco的comments。
Lasted upper is uneven拉帮不顺
Snake material nebulization by solvent蛇纹洗雾
Heel wrapped not smooth跟包边不平顺 Less cementing on insock paw part中皮、鞋垫前掌欠胶
Bad outsole edge paint 大底涂边不良 Outside height different外侧高度不一致 over solvent/primer溢处理剂(此处是指处理剂处理太过，连无需处理的地方也打了处理剂)
Impurity in outsole大底有杂质 Bad stitching车线掉边
Bad stitching on bowknot蝴蝶结车线掉边 Lasered not clean雷射杂物
Outsole stick too forward大底贴太前 Outsole stick too back 大底贴太后